RFTURBO engine — LW 2.0 diesel (2L)
2L · 101-136 hp
Engine overview
Vehicles with this engine
Factory specifications
Values from the manufacturer documentation for this engine.
Engine (general)
| Engine code | RF Turbo |
| Capacity | 1998 cc |
| Idle speed | 750 - 800 rpm |
| Inlet | 0.12 - 0.18 mm |
| Exhaust | 0.32 - 0.38 mm |
| Normal | 29.5 bar |
| Minimum | 26.5 bar |
| Oil pressure | 1.5 / 1000 3.5 / 3000 bar/rpm |
Engine (diesel)
| Injection pump (make and type) | Mazda |
| Injection pump timing (static) | 7 ° ATDC |
| Injector pressure | 165 - 185 bar |
| Oil temperature during test | 60 °C |
| Idle speed, minimum | 750 rpm |
| Idle speed, maximum | 800 rpm |
| Min. no-load governed speed | 4900 rpm |
| Max. no-load governed speed | 5180 rpm |
| Exhaust gas analysis | 2.50 m-1 |
| Exhaust gas analysis test method (Germany only) | B |
Cooling system
| Cap pressure | 0.95 - 1.25 bar |
| Thermostat opens at | 80 - 84 °C |
| Thermostat fully open at | 95 °C |
Electrical
| Battery | 64 / 70 Ah |
| Alternator | 70 A |
Capacities
| Engine sump, incl. filter | 4.7 l |
| Gearbox refill | 2.7 l |
| Cooling system | 9.0 l |
| Air-conditioner refrigerant | 650 g |
| Air-conditioner compressor oil | 150 ml |
Torque settings
| Cylinder head bolts — Stage 1 | 29 Nm |
| Cylinder head bolts — Stage 2 | 95° ° |
| Cylinder head bolts — Stage 3 | 95° ° |
| Front hub | 236 - 318 Nm |
| Rear hub | 177 - 235 Nm |
| Wheel nuts | 87 - 118 Nm |
| Injector nozzle | 52 - 60 Nm |
| Glow plugs | 15 - 19 Nm |
| Manual transmission drain plug | 40 - 58 Nm |
| Oil plug | 30 - 40 Nm |
Emissions
| Emission code | 70/220*1996/69 |
| Emission standard | Euro 2 |
| CO2 average | 158 g/km |
| CO | 0.781 g/km |
| HC NOx | 0.810 g/km |
| Particles | 0.073 g/km |
Workshop procedures for this engine
Step-by-step procedures from the workshop database.
Got a RFTURBO problem? Ask for free.
Describe the symptoms — TorqFix replies with a diagnosis cited from verified workshop data.
Get free diagnosis →Who makes these pages, and how
TorqFix was built by a mechanic — after a 2,700 km drive with five roadside repairs that no diagnostic tool could explain.
The figures on this page come from manufacturer workshop documentation and are shown as they are. The page is assembled automatically from that data — it is not written by an AI. The AI works in the chat, where it answers for your specific car. It writes nothing here.
Variants of the same model differ. Cross-check torque against the factory manual for your engine before final tightening.
Seen a figure that does not match your manual? Write to us — we correct it and note when. support@torqfix.com
The story behind TorqFix →Workshop data on this page last updated 22 Aug 2026.